Product ID:ALL CLIMATE SAE 15W40
MSDS Date:01/21/1998
FSC:9150
NIIN:00N091428
Status Code:A
MSDS Number: CJLCK

Emergency Phone: 800-274-5263

Info Phone: 606-357-7847

Cage: 72527

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

MINERAL OIL, PETROLEUM DISTILLATES (SEVERE) SOLVENT-DEWAXED

CAS: 64742-65-0

RTECS: PY8038501

DETERGENT/DISPERSANT ENGINE OIL PACKAGE

PHOSPHORODITHIOIC ACID, O,O-DI-C1-14-ALKYL ESTERS, ZINC

CAS: 68649-42-3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: UNLIKELY TO CAUSE EYE IRRITATION
OR INJURY. SKIN: MAY CAUSE MILD SKIN IRRITATION. PROLONGED OR
REPEATED CONTACT MAY DRY SKIN. SYMPTOMS MAY INCLUDE REDNESS,
BURNING, DRYING AND CRACKING OF SKIN & SKIN BURNS. INGEST:
SWALLOWING SMALL AMOUNTS OF THIS MATERIAL DURING NORMAL HANDLING IS
NOT LIKELLY TO CAUSE HARMFUL EFFECTS. SWALLOWING LARGE AMOUNTS MAY
BE HARMFUL. THIS MATERIAL CAN ENTER THE LUNGS DURING SWALLOWING OR
VOMITING AND CAUSE LUNG INFLAMMATION &/OR DAMAGE. INHAL: IT IS
POSSIBLE TO BREATHE THIS MATERIAL UNDER CERTAIN CONDITIONS OF
HANDLING & USE (FOR EXAMPLE, DURING HEATING, SPRAYING OR
STIRRING). (EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZS: SYMPTOMS USUALLY OCCUR AT AIR
CONCENTRATIONS HIGHER THAN THE RECOMMENDED EXPOSURE LIMITS (SEE
SECTION ON EXPOSURE CONTROLS/PERSONAL PROTECTION). SYMPTOMS OF
EXPOSURE: STOMACH OR INTESTINAL UPSET (NAUSEA, VOMITING,
DIARRHEA), IRRITATION (NOSE, THROAT, AIRWAYS), PAIN IN THE ABDOMEN.
TARGET ORGAN EFFECTS: NO DATA. DEVELOPMENTAL INFO: NO DATA. CANCER
INFO: USED MOTOR OIL HAS BEEN SHOWN TO C AUSE SKIN CANCER IN LAB
ANIMALS CONTINUALLY EXPOSED BY REPEATED APPLICATIONS. AVOID
PROLONGED OR REPEATED SKIN CONTACT. OTHER HEALTH EFFECTS: NO DATA.
PRIMARY ROUTE(S) OF ENTRY: NO DATA.

First Aid:EYES: IF SYMPS DEVELOP, MOVE INDIVIDUAL AWAY FROM EXPOS &
INTO FRESH AIR. FLUSH EYES GENTLY W/WATER FOR AT LEAST 15 MIN WHILE
HOLDING EYELIDS APART. IF SYMPS PERSIST OR THERE IS ANY VISUAL
DFCLTY, SEE K MED ATTN. SKIN: REMOVE CONTAM CLTHG. WASH EXPOS AREA
W/SOAP & WATER. IF SYMPS PERSIST, SEEK MED ATTN. LAUNDER CLTHG
BEFORE REUSE. INGEST: DO NOT INDUCE VOMIT. MATL IS ASPIR HAZ. IF
INDIVIDUAL IS DRO WSY/UNCON, PLACE ON LEFT SIDE W/HEAD DOWN. SEEK
MED ATTN. IF POSS, DO NOT LEAVE INDIVIDUAL UNATTENDED. INHAL: IF
SYMPS DEVELOP, IMMED MOVE INDIVIDUAL AWAY FROM EXPOS & INTO FRESH
AIR. SEEK IMMED MED A TTN; KEEP PERSON WARM & (SUPDAT)

Flash Point Method:COC
Flash Point:>215.6C, 420.F
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER OR FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT
AND POSSIBLY ENDANGER THE LIFE OF THE FIREFIGHTER. REFER TO THE
PERSONAL PROTECTIVE EQUIPMENT SECTION OF THIS MSDS.
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PROD (EVEN JUST RESIDUE) CAN IGNITE
EXPLOSIVELY. DENSE SMOKE MAY BE GENERATED WHILE BURNING. HAZ PRODS
OF COMBUST: MAY FORM: CARBON DIOXIDE & CARBON MONOXIDE, OXIDES OF
SULFUR, NITROGEN & PHOSPHORUS, VARIOUS HYDROCARBS. NFPA RATING:
(SUPDAT)

Spill Release Procedures:SMALL SPILL: ABSORB LIQ ON VERMICULITE, FLOOR
ABSORB OR OTHER ABSORB MATL. LARGE SPILL: PVNT RUN-OFF TO SEWERS,
STREAMS OR OTHER BODIES OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER
AUTHS AS REQD, THAT S PILL HAS OCCURED. PERSONS NOT WEARING PROT
EQUIP SHOULD BE EXCLUDED FROM AREA OF SPILL UNTIL CLEAN-UP HAS BEEN
COMPLETED. STOP SPILL AT SOURCE, DIKE AREA OF SPILL TO PVNT
SPREADING, (SUPDAT)

Handling and Storage Precautions:HANDLING: CONTAINERS OF THIS MATERIAL
MAY BE HAZARDOUS WHEN EMPTIED. SINCE EMPTIED CONTAINERS RETAIN
PRODUCT RESIDUES (VAPOR, LIQUID, AND/OR SOLID), ALL HAZARD
PRECAUTIONS GIVEN IN THE DATA SHEET MUST BE OBSERVED. STORAGE: NOT
APPLICABLE.

Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
HOWEVER, IF OIL MISTS ARE GENERATED ABOVE RECOMMENDED PEL/TLV OF 5
MG/M3, THEN A NIOSH APPROVED RESPIRATOR IS ADVISED IN ABSENCE OF
PROPER ENVIRONMENTAL CO NTROL. (SEE YOUR INDUSTRIAL HYGIENIST.)
Ventilation:NOT REQD UNDER NORM CNDTNS OF USE. HOWEVER, IF UNUSUAL
OPERATING CNDTNS EXIST, PROVIDE SUFFICIENT MECH (GEN &/OR LOC
EXHST) VENT TO MAINTAIN (OTHER INFO)
Protective Gloves:RESISTANT GLOVES SUCH AS NITRILE RUBBER.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
SKIN PROTECTION: NOT NORMALLY REQUIRED. WEAR NORMAL CLOTHING
COVERING ARMS AND LEGS.
Supplemental Safety and Health
FIRST AID PROC: QUIET. IF PERSON IS NOT BRTHG, BEGIN ARTF RSP. IF BRTHG
DFCLT, ADMIN OXYGEN. NOTE TO MD: NO DATA. EXPLO HAZ: HEALTH -1;
FLAM:1; REACTIVITY:0. SPILL PROC: PUMP LIQ TO SALVAGE TANK. REMA
INING LIQ MAY BE TAKEN UP ON SAND, CLAY, EARTH, FLOOR ABSORB OR
OTHER ABSORB MATL & SHOVELED INTO CNTNRS.

Boiling Pt:B.P. Text:NO DATA
Vapor Pres:NO DATA
Spec Gravity:0.88
Viscosity:3000 CPS; 14.5-15.5 CST
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:AMBER LIQUID; PETROLEUM ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY FORM: CARBON DIOXIDE AND CARBON
MONOXIDE, OXIDES OF SULFUR, NITROGEN AND PHOSPHORUS, VARIOUS
HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE AND FEDERAL REGULATIONS.

Toxicological Information:NO DATA.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO DATA.

Transport Information:DOT INFORMATION - 49 CFR 172.101. DOT
DESCRIPTION: NOT REQULATED. CONTAINER/MODE: CASES/SURFACE. NOS
COMPONENT: NONE. RQ (REPORTABLE QUANTITY) - 49 CFR 171.201 NOS
COMPONENT: NONE. RQ (REPORTABLE QUAN TIFY) - 49 CFR 172.101: NOT
APPLICABLE.

SARA Title III Information:SARA 302 COMPONENTS - 40 CFR 355 APPENDIX A:
NONE. SECTION 313/312 HAZARD CLASS - 40 CFR 370.2.IMMEDIATE,
DELAYED. SARA 313 COMPONENTS - 40 CFR 372.65 - SECTION 313
COMPONENT(S): ZINC C1-C14 ALKYDITHI OPHOSPHATE, CAS # 68649-42-3 -
MAX WT % 1.39.
Federal Regulatory Information:TSCA (TOXIC SUBSTANCES CONTROL ACT)
STATUS - TSCA (UNITED STATES) THE INTENTIONAL INGREDIENTS OF THE
PRODUCT ARE LISTED. CERCLA RQ:40 CFR 302.4: NONE. INTERNATIONAL
REGULATIONS; INVENTORY STATUS: NOT DETERMINED.
State Regulatory Information:CALIFORNIA PROPOSITION 65: NONE.